Studies on development of drying system using the far-infrared heater for agricultural products
| Project/Area Number |
05556043
|
|---|
| Research Category |
Grant-in-Aid for Developmental Scientific Research (B)
|
| Allocation Type | Single-year Grants |
|---|
| Research Field |
農業機械学
|
|---|
| Research Institution | Okayama University |
|---|
Principal Investigator |
MOHRI Kentaro Okayama Univ.Faculty of Agr.Prof., 農学部, 教授 (20081531)
|
|---|
| Co-Investigator(Kenkyū-buntansha) |
MONTA Mituji Okayama Univ.Faculty of Agr.Assist.Prof., 農学部, 助手 (80239714)
KONDO Naoshi Okayama Univ.Faculty of Agr.Research farm Assoc.Prof., 農学部附属農場, 助教授 (20183353)
SHIBANO Yasunori Okayama Univ.Faculty of Agr.Prof., 農学部, 教授 (00033332)
NAMBA Kazuhiko Okayama Univ.Faculty of Agr.Assist.Prof., 農学部, 助手 (90263623)
|
|---|
| Project Period (FY) |
1993 – 1995
|
| Project Status |
Completed (Fiscal Year 1995)
|
| Budget Amount *help |
¥6,800,000 (Direct Cost: ¥6,800,000)
Fiscal Year 1995: ¥800,000 (Direct Cost: ¥800,000)
Fiscal Year 1994: ¥1,000,000 (Direct Cost: ¥1,000,000)
Fiscal Year 1993: ¥5,000,000 (Direct Cost: ¥5,000,000)
|
|---|
| Keywords | Far-infrared / Drying method / Agricultural products / Sweet potato drying / Rough rice drying / SHIITAKE mushroom drying / Laver drying |
|---|
| Research Abstract |
This research studies on the drying system using the far-infrared heater and drying of agricultural products. This study is the most interesting research subject in Japan.
This developmental scientific research was accomplished for three years. There were to make the trial manufacture of drying equipment with far-infrared heater and to establish the drying method for rough rices, sweet potatoes, SHIITAKE mushrooms and lavers using the drying equipment with far-infrared heater.
In heating experiment of sweet potatoes, surface and inside temperatures of supplied materials were higher than the air temperatures inside drying room. This fact was considered a special characteristics of far-infrared drying.
Maximum reduse ratio of moisture content per one hour for rough rice drying was 17.7%/h. Sweet potoes were dried the moisture content of 20% for 6-9 hours. SHIITAKE mushrooms drying by far-infrared heater were done a method which imitated the tradisional drying method by heating air, and the period of drying by far-infrared was shorter than the drying by heating air. In SHIITAKE mushroom drying, far-infrared drying was an effective drying method. For laver drying, a method according to use far-infrared heater could be established by this research, and was an effective method.
|
Report
(4 results)
Research Products
(9 results)
