SYNERGISTIC EFFECT OF CARBON-BASED ULF-SOLID LUBRICANTS IN AN SPACE ENVIRONMENT
| Project/Area Number |
17360410
|
|---|
| Research Category |
Grant-in-Aid for Scientific Research (B)
|
| Allocation Type | Single-year Grants |
|---|
| Section | 一般 |
|---|
| Research Field |
Aerospace engineering
|
|---|
| Research Institution | Kobe University |
|---|
Principal Investigator |
TAGAWA Masahito Kobe University, DEPARTMENT OF MECH. ENG, ASSOCIATE PROFESSOR (10216806)
|
|---|
| Co-Investigator(Kenkyū-buntansha) |
YOKOTA Kumiko KOBE UNIV, DEPARTMENT OF MECH ENG, RESEARCH ASSOCLATE (20252794)
|
|---|
| Project Period (FY) |
2005 – 2007
|
| Project Status |
Completed (Fiscal Year 2007)
|
| Budget Amount *help |
¥13,860,000 (Direct Cost: ¥13,200,000、Indirect Cost: ¥660,000)
Fiscal Year 2007: ¥2,860,000 (Direct Cost: ¥2,200,000、Indirect Cost: ¥660,000)
Fiscal Year 2006: ¥3,600,000 (Direct Cost: ¥3,600,000)
Fiscal Year 2005: ¥7,400,000 (Direct Cost: ¥7,400,000)
|
|---|
| Keywords | Diamond-like Carbon / Atomic oxygen / Space Environment / Ultralow Friction / Low Earth Orbit / 紫外線 |
|---|
| Research Abstract |
The purpose of this research is to clarify the tribological properties of diamond-like carbon (DLC) films in a space environment. Hydrogenated-DLC samples were exposed to the 5 eV atomic oxygen beam, which simulated the environment at the upper atmospheric condition of Earth, and the change in surface properties were measured by synchrotron radiation photoemission spectroscopy (SR-PES), Rutherford backscattering spectroscopy (RBS) and elastic recoil detection analysis (ERDA). It was identified that the carbon atom, which is chemically bonded with oxygen, is not a major carbon state even after atomic oxygen exposure. This experimental result can be explained by the fact that the oxidation reaction of carbon with hyperthermal atomic oxygen restricted at the topmost layer of the DLC surface. In contrast, it was clearly indicated by RBS that the DLC film itself was lost by the hyperthermal atomic oxygen exposure. NEXFS measurement revealed that the sp2/sp3 ratio decreased with atomic oxygen exposures. From these results, it was estimated that the highly reactive part in DLC (amorphous phase) is selectively gasified by atomic oxygen and the stable carbon frame (diamond phase) is left on the surface (selective gasification reaction). This conclusion is supported by the results of STS-8 flight mission which indicates that the erosion rate of diamond is less than 5 % of amorphous carbon. The energy dependence of the gasification reaction was also investigated in this study. It was also demonstrated that the reaction yield of gasification reaction of DLC with oxygen atom increased exponentially with its collision energy. The experimental data obtained in this project indicated that the non-protected DLC would not be survived in the low Earth orbit space environment. For protecting DLC from such a highly oxidative environment, doping of metallic atoms such as Si- or Ti-atom would be effective. This hypothesis will be evaluated in the following project.
|
Report
(4 results)
Research Products
(46 results)
-
-
-
-
-
-
[Journal Article] Spacc environmental effects on r1SoS2 and diamond-like carbon lubricating films -atomic oxygen-induced erosion2007
Author(s)
Tagawa, M., Yokota, K., Matsumoto, K., Suzuki, M., Teraoka, Y, Kitamura, A., Belin M., Fontaine J., Martin J-M
-
Journal Title
Surface and Coating Technology Vol. 202
Pages: 1003-1010
Description
「研究成果報告書概要(欧文)」より
Related Report
-
[Journal Article] Direct insertion of oxygen atoms into the backhands of surface Si atoms using translational energies of oxygen atom beams2007
Author(s)
Tagawa ,M., Yokota, K., Tsumamoto, S., Sogo, C., Yoshigoe, K, Teraoka, Y
-
Journal Title
Applied Physics Letters Vol. 91
Pages: 33504-33504
Description
「研究成果報告書概要(欧文)」より
Related Report
-
[Journal Article] Atomic beam-induced fluorination ofpolyimide ano its application to site-selective Cu metallization2007
Author(s)
Tagawa, M., Maeda, K, Kajita, T., Yokota, K., Akamatsu, K., Nawafune, H
-
Journal Title
Langmuir Vol. 23 No. 23
Pages: 11351-11354
Description
「研究成果報告書概要(欧文)」より
Related Report
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
[Presentation] Performance alteration of MoSs solid lubricant due to long exposure duration to LEO space environment aboard ISS2007
Author(s)
Matsumoto, K. Bela, M., Fontaine, J., Le, Mogne T., Suzuki, M., Tagawa, M
Organizer
34th Leeds-Lyon Symposium, Lyon
Description
「研究成果報告書概要(欧文)」より
Related Report
-
[Presentation] Surface modification of a diamond-like carbon thin Elm using ht perthermal fluorine beams2007
Author(s)
Yamada, N., Kanda, K, Yokota, K., Tagawa, M., Niibe, M., Haruyama, Y., Matsui, S
Organizer
20th International Microprocesses and nanotechnology Conference
Place of Presentation
Kyoto
Description
「研究成果報告書概要(欧文)」より
Related Report
-
[Presentation] Fluorination of PMDA-ODA Polyimide using Hyperthermal Atomic Fluorine Beams2007
Author(s)
Tagawa, M., Yokota, K., Maeda, K., Yoshigoe, A., Teraoka, Y., Akamatsu, K., Nawafnne, H
Organizer
5th International Conference on Polyimides and Other High Temperature Polymers
Place of Presentation
Orlando
Description
「研究成果報告書概要(欧文)」より
Related Report
-
[Presentation] Durability of a Silicon-Containing Polcimide in a Simulated Low Earth Orbit Space Environment2007
Author(s)
Yokota, K., Tagawa, M., Iwata, M., Miyazaki, E., Ishizawa, J., Suzuki, M., Yokota, R
Organizer
5th International Conference on Polyimides and Other High Temperature Polymers
Place of Presentation
Orlando, FL
Description
「研究成果報告書概要(欧文)」より
Related Report
-
-
-
-
-
-
[Book] DLC膜ハンドブック2006
Author(s)
田川雅人, 他
Total Pages
601
Publisher
エヌ・ティ・エス
Description
「研究成果報告書概要(和文)」より
Related Report
-
-
-
-
-
