Heat Transfer on Mixed-salts Aqueous Solutions of Lithium bromide and chloride under Saturate Nucleate Pool Boiling with Effect of Marangoni Convection.

• Project/Area Number: 17560192
• Research Category: Grant-in-Aid for Scientific Research (C)
• Allocation Type: Single-year Grants
• Section: 一般
• Research Field: Thermal engineering
• Research Institution: Shibaura Institute of Technology
• Principal Investigator: KAMOSHIDA Junji Shibaura Institute of Technology, College of Engineering, Professor (30052856)
• Co-Investigator(Kenkyū-buntansha): SHOJI Masahiro University of Kanagawa, Faculty of Engineering, Professor (00011130) ; KAWAGUCHI Yasuo Tokyo University of Science, Faculty of Science and Technology, Professor (20356835) ; 鈴木 健二郎 芝浦工業大学, 工学研究科, 教授 (00026064)
• Project Period (FY): 2005 – 2007
• Project Status: Completed (Fiscal Year 2007)
• Budget Amount: ¥3,610,000 (Direct Cost: ¥3,400,000、Indirect Cost: ¥210,000); Fiscal Year 2007: ¥910,000 (Direct Cost: ¥700,000、Indirect Cost: ¥210,000); Fiscal Year 2006: ¥1,100,000 (Direct Cost: ¥1,100,000); Fiscal Year 2005: ¥1,600,000 (Direct Cost: ¥1,600,000)
• Keywords: Pool nucleate boiling / Bubble diameter at detachment / Three Phase Contact line / Bubble erowthine rate / Liquid-vapor interuhase / Surface tension eradient / Bubble risine velocit / 気泡上昇速度 / 気泡 / 熱伝達特性 / 沸騰様相 / 溶液濃度 / 発泡点密度 / 離脱気泡径 / 気泡サイクル / 無次元整理式

Research Abstract

In the advantage, the boiling heat transfer study has the long history, and the liquid which the study does with the object crosses many materials such as not only water but also refrigerant, organic solvent.
However, the study example is little, since there are many uncertain problems which made high boiling point, high corrosiveness and concentration in the heating surface vicinity to be a beginning even in the inside which is abounding of that the liquid as an object is also aqueous solution on the industry on multi-component system liquid, it is for inorganic salt aqueous solution.
Especially, though lithium system saline aqueous solution is widely used as an absorption solution of absorption water heater-chiller, as a influencial factor of nucleate boiling heat transfer characteristics which controls the performance of reproduction apparatus of absorption cooler and warmer, it has sufficiently and not yet obtained a knowledge of concentration and pressure widely crossed.
In this report, nucleate pool boiling heat transfer experiment of each aqueous solution which changed composition ratio of the mixed salt for lithium bromide and lithium chloride was carried out, and the relationship between boiling heat transfer characteristics and composition ratio was clarified.
In addition, nucleate pool boiling heat transfer characteristic under the pressurization for the high concentration aqueous solution of lithium bromide and chloride were clarified experimentally.
As the result, dimensionless correlation system on mixed salt aqueous solution was proposed from the relationship between boiling heat transfer characteristics and bubble population density. Lithiumu halide aqueous solution was proposed from the relationship between boiling heat transfer characteristics and bubble population density.

Research Products

• [Journal Article] CHF付近における蒸気塊底部の液層構造 (2007)
  • Author(s): 井出 幸佑, 鴨志田 隼司, 弓座 京子
  • Journal Title: Thermal science and engineering 15 Pages: 15-22
  • NAID: 10018576174
  • Description: 「研究成果報告書概要(和文)」より
  • Peer Reviewed
• [Journal Article] A Study of Liquid-layer Structures under Vapor mass in CHF region. (2007)
  • Author(s): K., Ide, J., Kamoshida, K., Yumiza
  • Journal Title: Thermal Science & Engineering, 15-1 Pages: 15-22
  • NAID: 10018576174
  • Description: 「研究成果報告書概要(欧文)」より
• [Journal Article] CHF附近における蒸気塊底部の液層構造 (2007)
  • Author(s): 井出幸佑, 鴨志田隼司, 弓座京子
  • Journal Title: Thermal Science and Engineering(日本電熱学会論文集) 15・1 Pages: 15-22
• [Journal Article] Study of Flow Structure Relating to the Heat and Mass Transfer in Micro Liquid Films In Marangoni Drying of Silicon Wafer (2006)
  • Author(s): Y.Miyamoto, N.Nagai, J.Kamoshida, K.Suzuki
  • Journal Title: Proceedings of 13th International Heat Transfer Conference, Sydney, (2006) (CD-ROM)MPH-33 Pages: 1-10
  • Description: 「研究成果報告書概要(和文)」より
  • Peer Reviewed
• [Journal Article] Study of Flow Structure Relating to the Heat and Mass Transfer in Micro Liquid Films in Marangoni Drying of Silicon Wafer. (2006)
  • Author(s): Y., Miyamoto, H., Nagai, J., Kamoshida, K., Suzuki
  • Journal Title: Proceedings of 13th International Heat Transfer Conference MPH-33(CD-ROM) Pages: 1-10
  • Description: 「研究成果報告書概要(欧文)」より
• [Journal Article] Study of structure relation to the heat and mass transfer in micro liquid films in Marangoni dying processes of silicon wafer (2006)
  • Author(s): Y.Miyamoto, H.Nagai, J.Kamoshida, K.Suzuki
  • Journal Title: 13^<th> International Heat Transfer Conference(MPH-33) Pages: 1-10
• [Journal Article] Heat transfer on mixed salts solution of Lithiumu Bromide and Chloride under saturation pool boiling (2005)
  • Author(s): Kamoshida, J., Itoho, G., Shibata, T., Isshiki, N.
  • Journal Title: Proceedings of the international sorption heat pump conference, Denver, (2005) (CD-ROM)ISHP-023 Pages: 1-8
  • Description: 「研究成果報告書概要(和文)」より
  • Peer Reviewed
• [Journal Article] Attainable maximum heat flux of pool nucleate boiling on heated wire (2005)
  • Author(s): Shoji, M., Wtanabe, M., Tang, M., Kamoshida, J., and Sasaki, K.
  • Journal Title: Proceedings of the 2nd symosium on thermal science and technology, Beiijin, (2005) Pages: 30-34
  • Description: 「研究成果報告書概要(和文)」より
  • Peer Reviewed
• [Journal Article] Isshiki, Heat Transfer on Mixed-salts Aqueous Solutions of Lithium Bromide and Chloride under pool Saturate Boilimg. (2005)
  • Author(s): J., Kamoshida, G., Itho, T., Shibata., N
  • Journal Title: Proceedings of International Sorption Heat Pump Conference ISHP-023-2005(CD-ROM) Pages: 1-8
  • Description: 「研究成果報告書概要(欧文)」より
• [Journal Article] Attainable Maximum Heat Flux of Pool Nucleate Boiling on a Heated Wire. (2005)
  • Author(s): M., Shoji, M., Tange, M., Watanabe, J., Kamoshida, K., Sasaki
  • Journal Title: Proceedings of the 2nd International Symposium on Thermal Science and Engineering Pages: 30-34
  • Description: 「研究成果報告書概要(欧文)」より
• [Journal Article] Heat Transfer on Mixed Salts Aqueous Solutions of Lithium Bromide and Chloride under Saturation Nucleate Pool Boiling (2005)
  • Author(s): Kamoshida, J., Itoho, G., Shibata, T., Isshiki, N.
  • Journal Title: Proceedings of the International Sorption Heat Pump Conference Pages: 1-8
• [Journal Article] Attainable Maximum Heat Flux of Pool Nucleate Boiling on A Heated Wire (2005)
  • Author(s): M., Shoji, M., Watanabe, M., Tange J., Kamoshida, K., Sasaki
  • Journal Title: Proceedings of the 2^<nd> Symposium on Thermal Science and Technology Pages: 23-25
• [Presentation] プール沸騰における三相界線近傍の気泡観察 (2007)
  • Author(s): 鴨志田 隼司, 降旗 健司, 庄司 正弘, 川口 靖夫
  • Organizer: 日本機械学会熱工学部門熱工学コンファレンス2007
  • Place of Presentation: 京都京都大学
  • Year and Date: 2007-11-23
  • Description: 「研究成果報告書概要(和文)」より
• [Presentation] プール沸騰における三相界線近傍の気泡観察 (2007)
  • Author(s): 鴨志 田隼司、降旗 健司、庄司 正弘、川口 靖夫
  • Organizer: No.07-50本機械学会熱工学コンファレンス2007講演論文集
  • Place of Presentation: 京都大学工学部(京都)
  • Year and Date: 2007-11-23
• [Presentation] Observation of Vapor Bubble near Three Phase Contact Line in Pool Boiling (2007)
  • Author(s): J., Kamoshida, K., Furihata, M., Shoji, Y., Kawaguchi
  • Organizer: Proceedings of Thermal Engineering Conference '07
  • Place of Presentation: Kyoto
  • Description: 「研究成果報告書概要(欧文)」より
• [Presentation] 高熱流束プール核沸騰における液層構造の遷移過程 (2006)
  • Author(s): 鴨志田 隼司, 弓座 京子
  • Organizer: 日本機械学会熱工学部門熱工学コンファレンス2006
  • Place of Presentation: 横浜慶応大学
  • Year and Date: 2006-11-24
  • Description: 「研究成果報告書概要(和文)」より
• [Presentation] リチウム系塩類水溶液のプール核沸騰熱伝達特性 (2006)
  • Author(s): 柴田 隆雄, 鴨志田 隼司
  • Organizer: 第43回日本伝熱シンポジウム
  • Place of Presentation: 名古屋国際会議場
  • Year and Date: 2006-06-01
  • Description: 「研究成果報告書概要(和文)」より
• [Presentation] 大直径伝熱面におけるCHF付近の液層構造 (2006)
  • Author(s): 井出 幸佑, 鴨志田 隼司, 弓座 京子
  • Organizer: 第43回日本伝熱シンポジウム
  • Place of Presentation: 名古屋国際会議場
  • Year and Date: 2006-06-01
  • Description: 「研究成果報告書概要(和文)」より
• [Presentation] 加熱細線のサブクールプール沸騰における限界熱流束〜細線材質の影響〜 (2006)
  • Author(s): 佐々木 一裕, 丹下 学, 鴨志田 隼司, 渡辺 誠, 庄司 正弘
  • Organizer: 第43回日本伝熱シンポジウム
  • Place of Presentation: 名古屋国際会議場
  • Year and Date: 2006-06-01
  • Description: 「研究成果報告書概要(和文)」より
• [Presentation] Nucleate Pool Boiling Heat Transfer on Lithium Salt Solutions (2006)
  • Author(s): T., Shibata, J., Kamoshida
  • Organizer: Proceedings of 43rd Natinal Heat Transfer Symposium of Japan
  • Place of Presentation: Nagoya
  • Description: 「研究成果報告書概要(欧文)」より
• [Presentation] A Study of Liquid Layer Structures of CHF Region in a Large-diameter Heating Surface (2006)
  • Author(s): K., Ide., J., Kamoshida, K., Yumiza
  • Organizer: Proceedings of 43rd Natinal Heat Transfer Symposium of Japan
  • Place of Presentation: Nagoya
  • Description: 「研究成果報告書概要(欧文)」より
• [Presentation] Critical Heat Flux on Fine Heated Wire in Pool Subcooled Nucleate Boiling (2006)
  • Author(s): K., Sasaki, M., Tange, M., Watanabe, J., Kamoshida, M., Shoji
  • Organizer: Proceedings of 43rd Natinal Heat Transfe : Symposium of Japan
  • Place of Presentation: Nagoya
  • Description: 「研究成果報告書概要(欧文)」より
• [Presentation] A Study on Liquid Layer Structure Process from Vapor Mass Region to CHF in Nucleate Pool Boiling (2006)
  • Author(s): J., Kamoshida, K., Yumiza, K., Ide, K., Suzuki, M., Shoji, Y., Kawaguchi
  • Organizer: Proceedings of Thermal Engineering Conference '06
  • Place of Presentation: Yokohama
  • Description: 「研究成果報告書概要(欧文)」より