• 研究課題をさがす
  • 研究者をさがす
  • KAKENの使い方
  1. 課題ページに戻る

2023 年度 実施状況報告書

超高強度Mg-Gd-Y-Zn-Zr合金の疲労特性に関する基礎研究

研究課題

研究課題/領域番号 22KF0310
配分区分基金
研究機関九州大学

研究代表者

陳 強  九州大学, 工学研究院, 教授 (30264451)

研究分担者 CHEN YAO  九州大学, 工学研究院, 外国人特別研究員
研究期間 (年度) 2023-03-08 – 2025-03-31
キーワードMg-RE alloy / Very-high-cycle fatigue / Nano-precipitates / Crack nucleation / Damage accumulation
研究実績の概要

We investigated the very high cycle fatigue behavior of a long-period stacking ordered (LPSO) strengthened Mg alloy under both solution and aging conditions. The main microstructural difference between the two conditions is characterized by dense β' nano-precipitates under the aging condition. The fatigue strengths are comparable under both conditions, whereas the fatigue lives tend to be improved apparently under the aging condition. The improved fatigue lives under the aging condition are attributed to the dense β' nanoprecipitates, which delay the processes of crack initiation and early propagation. Plastic localization shows a continuous pattern along the damage bands under the solution condition, while it shows a scattered pattern along the damage bands under the aging condition due to the effect of β' nano-precipitates, which affect the fatigue crack nucleation mechanism.

現在までの達成度 (区分)
現在までの達成度 (区分)

2: おおむね順調に進展している

理由

As planned, macroscopic fatigue properties and damage localizations under solution and aging conditions have been investigated on the LPSO-strengthened Mg alloy. The results obtained have been submitted to the journal of Materials Science & Engineering A and International Journal of Fatigue. Further research will be conducted to improve the macroscopic fatigue properties through regulating the microstructure via heat treatment. On the whole, we have achieved the research goals set up for FY2023, and the progress of the project was partially advanced.

今後の研究の推進方策

Stacking faults (SFs) enhance non-basal dislocation sources in magnesium, addressing its ductility challenges. Therefore, we are interested in the fatigue response of the SFs-strengthened Mg alloy. We will systematically engineer two types of Mg alloy with the same laminated nanostructures: one with profuse SFs and one with dense LPSO lamellae. This will enable a comparative investigation of the fatigue response between the SFs-strengthened Mg and the LPSO-strengthened Mg. We are interested in which is more effective in enhancing the fatigue properties, and the corresponding fatigue mechanisms.

  • 研究成果

    (3件)

すべて 2023 その他

すべて 国際共同研究 (1件) 雑誌論文 (2件)

  • [国際共同研究] Sichuan University/Chengdu University(中国)

    • 国名
      中国
    • 外国機関名
      Sichuan University/Chengdu University
  • [雑誌論文] Fatigue-induced oxidation assisting microcrack nucleation in Mg-RE alloy under ultrasonic fatigue2023

    • 著者名/発表者名
      Chen Yao、Shuai Qi、Wu Yujuan、Peng Liming、Shao Xiaohong、Liu Fulin、He Chao、Li Lang、Liu Yongjie、Wang Qingyuan、Xie Shaoxiong、Chen Qiang
    • 雑誌名

      Scripta Materialia

      巻: 236 ページ: 115643~115643

    • DOI

      10.1016/j.scriptamat.2023.115643

  • [雑誌論文] Oxide nodule assisting fatigue crack initiation in hierarchical anisotropic nanostructured Mg-RE alloy2023

    • 著者名/発表者名
      Chen Yao、Shuai Qi、Wu Yujuan、Peng Liming、Shao Xiaohong、Liu Fulin、He Chao、Li Lang、Liu Yongjie、Wang Qingyuan、Xie Shaoxiong、Chen Qiang
    • 雑誌名

      International Journal of Fatigue

      巻: 175 ページ: 107820~107820

    • DOI

      10.1016/j.ijfatigue.2023.107820

URL: 

公開日: 2024-12-25  

サービス概要 検索マニュアル よくある質問 お知らせ 利用規程 科研費による研究の帰属

Powered by NII kakenhi